It's actually quite simple. The hardest part I found was removing the bolts from the caliper and was able to get them off with some liquid wrench and a socket wrench. Once you get the caliper off, take a small bungee cord and hook the caliper up on the spring so that you don't stretch or damage the brake line. The pads will just slide off. There are 2 clips and a thin plate (keep these).
Pay close attention and note how you removed the old pads as this is how you will put the new pads back on.
You might also want to check the rotors and make sure they have no grooves and are smooth. To be on the safe side it would not hurt to replace them, (31.99 each from Autozone), to replace the rotors it only requires the removal of the caliper bracket and 2 Philips head screws, then it slides right off and put the new one on and replace the screws and caliper bracket.
Make sure you grease the back of the pad and the plate. Now slide the new pads back on.
Now it is time to put the caliper back on. On the Kia Sedona there are 2 pistons per caliper. Remove the lid from the brake fluid reservoir. Take one of the old brake pads and place over the pistons then take the C-clamp and tighten it until each piston is fully pushed back in. You'll know if they aren't because the caliper will not go back over the new pads until they are. Also note that the brake pads will be flush up against the rotor.
Once the caliper is back on and bolted down reach in the van and press the brake pedal w/ your hand, (you really don't want to physically get in the van while it is jacked up) and press the pedal until you have solid pressure.
And that is it. Put your tire back on and take your van for a test drive.
The 2004 Kia Sedona has 40.6 in. of front leg room.
The 2004 Kia Sedona has 39.4 in. of front head room.
The 2004 Kia Sedona has 58.7 in. of front hip room.
The 2004 Kia Sedona has 58.4 in. of front shoulder room.
The front track of the 2004 Kia Sedona is 5 ft. 4.4 in. (64.4 in.).
Just had the front brakes and rotors replaced, rear brakes adjusted, 2004 Kia Sedona, $537 at a Kia dealer. You can get it cheaper from a good local mechanic, maybe $350.00 - $400.00.
what size allen wrench do i need to change front brakes on a 2004 dodge grand caravan
Is it like regular brakes are is there something special tool I need ?
The 2004 Kia Sedona has front wheel drive.
how to change airbags the kia sedona 2004
2004 sedona's have a tanny cooler in the front to keep it from overheating like a small rad if one of the lines are bad or damaged it will from the bumper (front) area
I just did this on my 03 sedona. If you are the original owner, they are covered under powertrain warranty.If you are not,the whole steering knuckle must come off and bearings will have to be pressed out and back in.